Please use this identifier to cite or link to this item: http://hdl.handle.net/11455/1599
DC FieldValueLanguage
dc.contributor.advisor盧昭暉zh_TW
dc.contributor.advisorJ.H. Luen_US
dc.contributor.author高銘傑zh_TW
dc.contributor.authorKao, Ming-Chiehen_US
dc.date2000zh_TW
dc.date.accessioned2014-06-05T11:41:12Z-
dc.date.available2014-06-05T11:41:12Z-
dc.identifier.urihttp://hdl.handle.net/11455/1599-
dc.description.abstract因LPG車輛所產生的排氣污染較相同的汽油車為低,對都會地區的空氣品質惡化問題有改善的作用。但在都會地區,機車對空氣污染的影響其實比汽車還要重要,而目前有關LPG的應用主要偏重在汽車,而對機車則尚未開始。 本文主要目的是進行引擎動力計實驗及實車改裝與測試的工作。此外,在本文中也將設計新的燃料系統。新系統先於引擎動力計上做測試,然後再進行LPG機車的行車型態排氣污染量測,包括目前管制的CO,HC,NOx,及目前並未管制的其他有害物質。由這些比較結果,將為都會地區改用液化石油氣燃料對空氣品質的影響有較堅實的評估依據。 本實驗計畫的工作包括:(1). LPG燃料系統設計,(2). 測試車輛組裝,及(3). LPG機車的排氣污染量測。燃料系統設計包括燃料桶,燃料管線系統, LPG減壓閥,蒸發器,流量控制閥,混合器設計,及燃料恆溫控制系統。在排氣成分分析方面,以GC/MS氣相質譜分析儀來找出HC之成分,汽油燃燒後成分中ethylene約佔21﹪,1-propene,2-methyl約佔11﹪,propene約佔8﹪,ethane成分佔7﹪左右。而LPG燃燒後成分中propane約佔62﹪,ethylene約佔11﹪,n-butane約佔9﹪,ethane約佔6﹪。因此在臭氧生成物方面,LPG引擎只佔汽油引擎的 80%左右。 由實驗結果可得到LPG引擎扭力與馬力值在中低轉速下其實和汽油引擎並無太大的差別,但在高轉速時LPG引擎的性能曲線下滑,比汽油引擎的性能低大約27%。而四行程機車引擎改用LPG燃料後,在廢氣中CO與HC的排放總量並不如預期能比汽油引擎理想,主要原因為燃料的特性與燃料系統及混合器的影響。zh_TW
dc.description.abstractDue to lower Exhaust Emission, the LPG vehicle is more helpful to improve the deteriorated air quality than gasoline vehicle, especially in the urban area. Recently, all LPG application was used in the automobile issue, not in motorbike. However, in the urban area, motorbike was more influential for air pollution than automobile. The following article is mentioned about experiment of engine and test of altered motorbike. New fuel system will be designed in this article as well. The new fuel system will be tested on the dynamometer, firstly and then on the exhaust emission of LPG motorbike, which was included the controlled CO, HC, NOX and other harmful but uncontrolled gas. From the result, it will offer more effective standard for evaluating air quality in the urban area, where was replaced using LPG in motorbike. The workings in this experiment are (1). Design of LPG fuel system. (2). Test of altered motorbike. (3). Measure of exhaust emission in LPG motorbike. Designs of fuel system are included: fuel tank, fuel wire system, LPG reduced pressure valve, evaporator, flow control valve, mixer design and fuel temperature control system. In the exhausted gas composition, HC was analyzed by GC/MS. The burned gasoline was with 21% of ethylene, 11% of 1-propene, 2-methyl, 8% of propene and 7% of ethane. The burned LPG was with 62% of propane, 11% of ethylene, 9% of n-butane and 6% of ethane. Therefore, the OFP (Ozone Forming Potential) of LPG engine was 20% lower than that of gasoline engine. Results of experiments showed that there is no significant difference in torque and power between LPG engine and gasoline engine in low and medium RPM. But, in high RPM, the performance curve of LPG engine was 27% lower than that of gasoline engine. Furthermore, the CO and HC emission in the waste gas was not as good as gasoline engine. The main reasons were the effect of fuel property and that the fuel system and mixer did not function well.en_US
dc.description.tableofcontents中文摘要………………………………………………………..i 英文摘要………………………………………………………iii 目錄…………………………………………………………….v 圖表目錄……………………………………………………..viii 第一章 緒論 1.1前言…………………………………………………………….1-1 1.2研究目的…………………………………………………….....1-5 1.3研究動機……………………………………………………….1-6 第二章 文獻回顧 2.1國內研究概況………………………………………………….2-1 2.2歐美研究概況………………………………………………….2-1 2.3日本研究概況………………………………………………….2-5 2.4國際SAE的LPG車輛競賽…………………………………..2-6 2.4.1 燃料系統………………………………………………….2-7 2.4.2 引擎修改………………………………………………...2-12 2.4.3 排氣污染………………………………………………...2-14 第三章 LPG機車燃料系統 3.1燃料桶……………………………………………………….…3-1 3.2蒸發器………………………………………………………….3-4 3.3流量控制閥…………………………………………………….3-6 3.4混合器………………………………………………………….3-6 第四章 實驗設備 4.1 四行程水冷式機車……………………………………………4-1 4.2 引擎動力計……………………………………………………4-2 4.3 廢氣分析儀……………………………………………………4-2 4.4 廢氣冷卻系統…………………………………………………4-3 4.5 空氣流量計……………………………………………………4-3 4.6 LPG流量計……………………………………………………4-3 4.7 數據擷取系統…………………………………………………4-4 第五章 實驗結果 5.1 實驗目的………………………………………………………5-1 5.2 不同的燃料系統設計參數對引擎性能的影響………………5-2 5.2.1 流量控制閥開度的影響………………………………….5-3 5.2.2 壓力調整閥的影響……………………………………….5-5 5.2.3 頂針長度的影響………………………………………….5-7 5.2.4混合器口徑的影響………………………………………..5-8 5.3 使用LPG與汽油引擎性能比較…………………………….5-11 5.3.1 汽車用燃料系統之LPG與汽油引擎性能比較………..5-11 5.3.2 自製燃料系統之LPG與汽油引擎性能比較…………..5-13 5.4 使用LPG與汽油引擎廢氣成分分析比較………………….5-13 5.5 改裝前後機車行車型態測試………………………………..5-15 5.6 機車污染排放的詳細成份分析……………………………..5-19 第六章 結論與未來研究方向 6.1 結論……………………………………………………………6-1 6.2 未來研究方向………………………………………………....6-3 參考文獻………………………………………………….…A-1 附錄一……………………………………………………….A-6 誌謝………………………………………………………….A-8zh_TW
dc.language.isoen_USzh_TW
dc.publisher機械工程學系zh_TW
dc.subjectLPGen_US
dc.subject液化石油氣zh_TW
dc.subjectFour Stroke Motorbikeen_US
dc.subjectExhaust Emissionen_US
dc.subject四行程機車zh_TW
dc.subject排氣污染zh_TW
dc.title液化石油氣(LPG)四行程機車zh_TW
dc.titleLiquid Petroleum Gas (LPG) Four Stroke Motorbikeen_US
dc.typeThesis and Dissertationzh_TW
Appears in Collections:機械工程學系所
文件中的檔案:

取得全文請前往華藝線上圖書館



Items in DSpace are protected by copyright, with all rights reserved, unless otherwise indicated.