Please use this identifier to cite or link to this item:
標題: Using intermittent ozonation to remove fouling of ultrafiltration membrane in effluent recovery during TFT-LCD manufacturing
作者: You, S.H.
Tsai, Y.T.
關鍵字: Membrane fouling;Ultrafiltration;Intermittent ozonation;TFT-LCD;flux decline;microfiltration;pretreatment;experience
Project: Journal of the Taiwan Institute of Chemical Engineers
期刊/報告no:: Journal of the Taiwan Institute of Chemical Engineers, Volume 41, Issue 1, Page(s) 98-104.
An ultrafiltration membrane process was used to treat the secondary effluent from the manufacturing of thin film transistor-liquid crystal display (TFT-LCD). A bench-scale system was performed to evaluate the efficiency of fouling removal by dosing tap water with ozone intermittently. It was observed that about 90% of the initial permeate flux was maintained after 120 min ozone washing, when the residual ozone concentration in the tap water flow was maintained at about 0.885 mg/L for 5 min ultrafiltration and 2.5 min ozone washing in every operation cycle. Ozone not only destroyed the fouling on the membrane, but also oxidized some solutes that had been adsorbed onto the inner pore fiber, especially with organic matter, thereby decreasing the fouling and increasing the permeate flux further. So, using intermittent ozonation can remove the fouling on ultrafiltration membranes and save the ozone consumption effectively. (C) 2009 Taiwan Institute of Chemical Engineers. Published by Elsevier B.V. All rights reserved.
ISSN: 1876-1070
DOI: 10.1016/j.jtice.2009.05.013
Appears in Collections:期刊論文

Show full item record

Google ScholarTM




Items in DSpace are protected by copyright, with all rights reserved, unless otherwise indicated.